Investigation of the Influence of Nickel on the Behavior of Thermal Donors in Silicon
Abstract
This work presents a comprehensive theoretical and experimental study of the behavior of nickel impurity atoms in the silicon crystal lattice. The focus is on analyzing diffusion mechanisms, the energetic characteristics of interstitial nickel atoms, their interaction with defects and other impurities, as well as the formation of stable clusters within the crystal volume. First-principles quantum mechanical modeling was employed using the QuantumATK software, applying the Linear Combination of Atomic Orbitals (LCAO) method and the Local Density Approximation (LDA) exchange-correlation functional. Special attention was given to calculating the binding energy of nickel atoms in interstitial sites and estimating the activation energy for their migration along various crystallographic directions ([100] and [010]). The modeling results revealed that nickel atoms predominantly diffuse in interstitial positions with an activation energy around 0.31 eV, which aligns well with previously reported experimental data. It was found that interactions of nickel with oxygen, carbon impurities, and point defects have a minimal impact on diffusion processes. However, interactions with vacancies lead to the formation of stable nickel silicides and cause an increased concentration of nickel near the surface.
The experimental part of the study confirmed the formation of nickel clusters under high-temperature treatments. Scanning Electron Microscopy (SEM), Secondary Ion Mass Spectrometry (SIMS), and Infrared (IR) microscopy revealed a high density and uniform distribution of clusters throughout the crystal volume. Cluster sizes ranged from 20 to 100 nm, with concentrations reaching approximately 1010 cm-3. These findings demonstrate that nickel acts as an effective gettering impurity, enhancing the electrophysical properties of silicon. The results provide valuable insights for optimizing the fabrication processes of high-efficiency silicon solar cells and microelectronic devices.
Downloads
References
J. Lindroos, D.P. Fenning, D.J. Backlund, et al., Nickel: “A very fast diffuser in silicon,” Journal of Applied Physics, 113(20), 204906 (2013). https://doi.org/10.1063/1.4807799
A.S. Astashenkov, D.I. Brinkevich, and V.V. Petrov, “Properties of Silicon Doped with Nickel Impurity by Diffusion,” Dokladi BGUIR, 38(8), 37-43 (2018). (in Russian)
B.K. Ismaylov, N.F. Zikrillayev, K.A. Ismailov, and Z.T. Kenzhaev, “Clusters of impurity nickel atoms and their migration in the crystal lattice of silicon,” Physical Sciences and Technology, 10(1-2), 13-18 (2023). https://doi.org/10.26577/phst.2023.v10.i1.02
K.A. Ismailov, N.F. Zikrillaev, B.K. Ismaylov, Kh. Kamalov, S.B. Isamov, and Z.T. Kenzhaev, “Nickel Clusters in the Silicon Lattice,” J. Nano- Electron. Phys. 16(5), 05022 (2024). https://doi.org/10.21272/jnep.16(5).05022
M.K. Bakhadyrkhanov, B.K. Ismaylov, S.A. Tachilin, K.A. Ismailov, and N.F. Zikrillaev, “Influence of electrically neutral nickel atoms on electrical and recombination parameters of silicon,” Semiconductor Physics, Quantum Electronics and Optoelectronics, 23(4), 361-365 (2020). https://doi.org/10.15407/spqeo23.04.361
M.G. Milvidsky, and V.V. Chaldyshev, “Nanometer-size atomic clusters in semiconductors—a new approach to tailoring material properties,” Semiconductors, 32(5), 513-522 (1998). https://doi.org/10.1134/1.1187418
B.K. Ismaylov, N.F. Zikrillayev, K.A. Ismailov, and Z.T. Kenzhaev, “Physical mechanism of gettering of impurity Ni atom clusters in Si lattice. Semiconductor Physics,” Quantum Electronics & Optoelectronics, 27(3), 294-297 (2024). https://doi.org/10.15407/spqeo27.03.294
N.A. Turgunov, E.Kh. Berkinov, and R.M. Turmanova, “The effect of thermal annealing on the electrophysical properties of samples n-Si,” East Eur. J. Phys. (3), 287 (2023). https://doi.org/10.26565/2312-4334-2023-3-26
V.V. Voronkov, G.I. Voronkova, A.V. Batunina, V.N. Golovina, M.G. Milvidskiy, et al., “Generation of thermal donors in silicon influence of self-interstitial atoms,” Fizika tverdogo tela, 42(11), 1965-1975 (2000). (in Russian)
V.B. Neymash, Ye.A. Puzenko, A.N. Kabaldin, A.N. Kraychinskiy, and N.N. Krasko, “On the nature of nuclei for the formation of thermal donors in silicon,” “Fizika i texnika poluprovodnikov”. 33.(12) 1423-1427 (1999). (in Russian)
V.M. Babich, et al., Oxygen in silicon single crystals, (Interpres LTD”, Ukraine, 1997), pp. 46.
P.A. Selishev, “Kinetics of formation of oxygen-containing thermodonors in silicon and formation of their non-uniform distribution,” Fizika i texnika poluprovodnikov, 35(1) 11-14 (2001). (in Russian)
Yu.A. Yakimov, and E.A. Klimanov, “Modeling of gettering processes of generation-recombination centers in silicon during diffusion of phosphorus and boron,” Prikladnaya fizika, 5(1), 15-20 (2015). (in Russian)
M.K. Bakhadirkhanov, Z.T. Kenzhaev, Kh.S. Turekeev, B.O. Isakov, and A.A. Usmonov, “Gettering properties of nickel in silicon photocells,” Technical Physics, 11(14), 2217-2220 (2021). https://doi.org/10.21883/JTF.2021.11.51529.99-21
I. Bayrambay, I. Kanatbay, K. Khayratdin, and S. Gulbadan, “Suppression of Harmful Impurity Atoms With Clusters of Nickel Impurity Atoms in a Silicon Lattice,” AIP Conference Proceedings, 2552, 060015 (2022). https://doi.org/10.1063/5.0129486
K.A. Ismailov, Z.T. Kenzhaev, S.V. Koveshnikov, E.Z. Kosbergenov, and B.K. Ismaylov, “Radiation Stability of Nickel Doped Solar Cells”, Physics of the Solid State, 64(3), 154–156 (2022). https://doi.org/10.1134/S1063783422040011
A. Galashev, and A. Vorobev, “Electronic properties and structure of silicene on Cu and Ni substrates,” Materials, 15(2), 3863 (2022). https://doi.org/10.3390/ma15113863
Z.T. Kenzhaev, Kh.M. Iliev, K.A. Ismailov, G.Kh. Mavlonov, S.V. Koveshnikov, B.K. Ismaylov, and S.B. Isamov, “Physical mechanisms of gettering properties of nickel clusters in silicon solar cells,” Physical Sciences and Technology, 11(1-2), 13-22 (2024). https://doi.org/10.26577/phst2024v11i1a2
Copyright (c) 2025 Bayrambay K. Ismaylov, Nurulla F. Zikrillayev, Kanatbay A. Ismailov, Zoir T. Kenzhaev, Alloberdi K. Saparov
This work is licensed under a Creative Commons Attribution 4.0 International License.
Authors who publish with this journal agree to the following terms:
- Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgment of the work's authorship and initial publication in this journal.
- Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgment of its initial publication in this journal.
- Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).
